Wilbur Curtis TCC1C Bruksanvisning

Wilbur Curtis Ikke kategorisert TCC1C

Les nedenfor 📖 manual på norsk for Wilbur Curtis TCC1C (12 sider) i kategorien Ikke kategorisert. Denne guiden var nyttig for 3 personer og ble vurdert med 4.3 stjerner i gjennomsnitt av 2 brukere

Last ned PDF
Side 1/12
NSF International requires the following water connection:
1. A quick disconnect or additional coiled tubing (at least 2x the depth of the unit) so that the machine
can be moved for cleaning underneath.
2. Thisequipmentistobeinstalledwithadequatebackowprotectiontocomplywithapplicable
federal, state and local codes..
3. Waterpipeconnectionsandxturesdirectlyconnectedtoapotablewatersupplyshallbesized,
installed and maintained in accordance with federal, state, and local codes.
1
Important Safeguards/Symbols
Service Manual, TCC
Thisapplianceisdesignedforcommercialuse.Anyservicingotherthancleaningandmaintenance
shouldbeperformedbyanauthorizedWilburCurtisservicecenter.
•DoNOTimmersetheunitinwateroranyotherliquid
•Nevercleanwithscouringpowders,bleachorharshchemicals.
Symbols:
WARNINGS – To help avoid personal injury Important Notes/Cautions
Sanitation Requirements
Curtis TCC Units are Factory Pre-Set and Ready to Go… Right out of the Box.
Generallytherewillneverbeareasontochangefactorysettings.However,shouldyouneedto
makeslightadjustmentstomeetyourteaneeds,adjustmentinstructionsareprovidedlaterinthis
manual.
SystemRequirements:
•WaterSource30–90PSI(MinimumFlowRateof1GPM).Ifincomingwatersupplyisgreater
than90PSI,additionalregulationisrequiredtomeettherange.
•Waterpipeconnectionsandxturesdirectlyconnectedtoapotablewatersupplyshallbe
sized,installedandmaintainedinaccordancewithfederal,state,andlocalcodes.
SETUP STEPS
Theunitshouldbelevel(lefttorightandfronttoback),locatedonasolidcountertop.Connecta
waterlinefromthewaterltertotheTCCserver.NOTE:Sometypeofwaterltrationdevicemust
beusedtomaintainatrouble-freeoperation.(Inareaswithextremelyhardwater,wesuggestthat
asedimentaryandtaste&odorlterbeinstalled.)Thiswillprolongthelifeofyoursystemand
enhanceteaquality.
INSTALLATION
1.Removedispenserfromcarton.
2.Runawaterlinetotheinletttingbehindthedispenser.Flushthenewwater-
line to remove foreign particles.
3.Connecta¼”aredexibleorcopperwaterlinetothemalettingontheback
of the dispenser.
4.Locatethewatersupplyvalvebehindtheunittoverifypositionisturnedon.
CAUTION:Werecommendedthatthewatersupplyvalve,behindunit,beturnedoffduring
non-business hours.
Wilbur Curtis Company, inC.
ModelsIncluded
•TCC1
•TCC2
•TCC3
NOTE:Watersource
pressure must be a
minimumof30PSI
pressure at all times
toinsurethequalityof
the of the product.
5.CleanouttheteaconcentratesystembeforeusingtheTCCserver.UseaBag-in-Box
stylecleaningsolutiontosimplifythecleaningprocedure.AcleanerlikeBevClean
beveragelinecleanercomesina3gallonbag-in-boxthatconnectsdirectlytoyour
bag-in-boxsystemforlinecleaning(http://bevclean.com).
a.Removethequickdisconnectfromtheteaconcentratebag.
b.PlacetheBIBcleanercontainernexttotheTCCteadispenser.Pullthespout
fromthecleanerboxthroughthemarkedarea.Removethecleartravelcapfrom
spout.Don’tworryaboutcleanerspillingwhenthecapisremoved.Thecaphas
an internal seal.
c. SnaptheQCDbagconnectorontothebagspout.
OFF
ON
ISO 9001:2008 REGIS-
TERED
WILBUR CURTIS CO., INC.
6913 West Acco Street
Montebello, CA 90640-5403
For the latest information go
to www.wilburcurtis.com
Tel: 800-421-6150
Fax: 323-837-2410
2
7. Carefullyliftthebagandsetthebagintothedispenser.
8. Resttubingontopofthebag.Routetubingtooppositeproductintake
holeonoorofdispenser(seeillustration,left).
9. Replacethetopcover.
10. Dispensebeveragefromfaucetuntildarkerproductstartstoappear(~5
seconds).
11. TheTCCserverisnowreadytodispensetea.
3. Pullofftheshipping
cap that covers the
spout on the bag.
4. PlacetheQCDnextto
the spout.
5. SlideQCDsideways,
over the bag spout.
QCDsnapsinplace.
6. PushQCDplungerinto
bag spout until plunger
topisushwithtopof
QCD.A“click”willbe
heardwhenitisfully
inserted.
LOAD PRODUCT
Bag-In-Box
1.PlaceateaconcentratebagonthecounternexttotheTCCdispenser.
2. RemovethetopcoverfromtheTCCdispenserandpulloutthehosewiththeQCD
bag connector.
d. Graspingthebagconnector(asshowninLoadProduct,step6),pushtheslidingprobeallthewayintothe
bagspout.A“click”willbeheardwhenitisfullyinserted.
e. Oncethecleaningsolutionboxisconnected,openthedispensingvalveonthedispenserandrunliquid
throughthevalveuntilthesanitizer(clearliquid)isdetected.Thedispensinglineisnowclean.
f. Disengagethebagconnectorbysnappingtheconnectorprobeoutandremovetheconnectorfromthespout.
g. ReattachtheteaconcentrateBIB.
h. Opendispensingvalveondispenseruntilteaowsfreely.
WATER PRESSURE AND MIXING VALVE
Thepressureregulatorshouldrarelybechanged.Primarytaste/brixadjust-
mentsshouldbedoneviathemixingvalvebyturningtherodandtastingthe
nishedproduct.98%ofavoradjustmentsshouldbedoneinthismanner.
The purpose of the regulator is to provide uniform water pressure so the venturi-
stylemixingdevicecanproduceastableanduniformblendofconcentrateand
waterandalsotoprotectthehydraulicsofthedispensingunitfrom“linepres-
sure”.Itisnottheprimaryadjustmentforthebrixlevel.Fromourtesting,ithas
beenshownthatexactPSIonthegagedoesnotdirectlycorrelatetoabrixlevel
from unit to unit and from installation location to installation location.
Secondarily,iftheprimaryadjustmentdoesn’tprovidetheidealbrixlevel,call
CurtisCareforinstructionsonhowtoadjusttheregulator.Asarule,verylittletasteadjust-
ment is achieved via the pressure regulator.
CAUTION: Do Not Exceed 25 psi (static). Equipmentfailureorleakagewill
result.

Produkspesifikasjoner

Merke: Wilbur Curtis
Kategori: Ikke kategorisert
Modell: TCC1C

Trenger du hjelp?

Hvis du trenger hjelp med Wilbur Curtis TCC1C still et spørsmål nedenfor, og andre brukere vil svare deg


Ikke kategorisert Wilbur Curtis Manualer

Wilbur Curtis

Wilbur Curtis GEM-3 Bruksanvisning

26 September 2025
Wilbur Curtis

Wilbur Curtis G4STB Bruksanvisning

26 September 2025
Wilbur Curtis

Wilbur Curtis WB5NLB Bruksanvisning

26 September 2025
Wilbur Curtis

Wilbur Curtis TCC3 Bruksanvisning

26 September 2025
Wilbur Curtis

Wilbur Curtis TCC1C Bruksanvisning

26 September 2025
Wilbur Curtis

Wilbur Curtis SW-1 Bruksanvisning

25 August 2025

Ikke kategorisert Manualer

Nyeste Ikke kategorisert Manualer

Leitz

Leitz 60780003 Bruksanvisning

27 September 2025
Hamilton Buhl

Hamilton Buhl VENU100M Bruksanvisning

27 September 2025
Samsung

Samsung AM26B2B2A Bruksanvisning

27 September 2025
T'nB

T'nB UMCHARGER1 Bruksanvisning

27 September 2025
Uniden

Uniden Oceanus DSC Bruksanvisning

27 September 2025
Uniden

Uniden GCVR4H40 Bruksanvisning

27 September 2025
Audio-Technica

Audio-Technica AT628a Bruksanvisning

27 September 2025
Audio-Technica

Audio-Technica AT6098a Bruksanvisning

27 September 2025
Uniden

Uniden GNVR4920W Bruksanvisning

27 September 2025
Hendi

Hendi 211571 Bruksanvisning

26 September 2025